Ranger RCI-6300F TB Manual do Utilizador

Ranger Communications Inc. RCI-6300F HP RCI-6300F TB 10 Meter Amateur Radio Ranger Service Manual

- 9 - 4 WIRE MIC CABLE Pin Number Mic Cable Lead 1 Audio Shield 2 Audio Lead 3 Transmit Control 4 Receive Control Figure 2-3 Your T

- 10 - 3.1 PLL CIRCUIT The Phase Lock Loop (PLL) circuit is responsible for developing the receiver’s first local oscillator signal and the transmit

- 11 -

- 12 -

- 13 - RCI-6300F HP / RCI-6300F TB FREQUENCY COUNTER CIRCUIT DIAGRAM

- 14 - RCI-6300F HP / RCI-6300F TB ECHO BOARD (EB-99) CIRCUIT DIAGRAM

- 15 - RCI-6300F HP RCI-6300F TB CHAPTER 4 ALIGNMENT 4.0 REQUIRED TEST EQUIPMENT ! DC Power Supply (13.8VDC, 20A) " RF Wattmeter (25~60 M

- 16 - ITEM U.U.T. SETTING ADJUST POINT MEASUREMENT TX Power Set radio to Fr Pool 2, CH 19 AM TX mode. Connect “short PCB” to TP7, TP8 and TP9. Con

- 17 - POINT AM Sensitivity Set radio to Fr Pool 2, CH 19 AM RX mode. Set RF Gain Fully Clockwise. Set SQ Fully Counter Clockwise. Set VOL Control a

- 18 - Figure 4-2 Receiver test setup

- 1 - RCI-6300F HP RCI-6300F TB TABLE OF CONTENTS PAGE CHAPTER 1 SPECIFICATIONS 1.0 General . . . . . . . . . . . . . . . . . . . . . . .

- 19 - Figure 4-3 Main PCB Adjustment Location

- 20 - RCI-6300F HP RCI-6300F TB CHAPTER 5 MAINTENANCE 5.0 PRECAUTIONS The inherent quality of the solid-state components used in this transcei

- 21 - RCI-6300F TB PARTS LIST 6.0 GENERAL Information on most electrical and mechanical parts is included in the parts list. The reference desig

- 22 - PART LIST: RCI-6300F HP / RCI-6300F TB ROTARY SW P.C.B ITEM REFERENCE NUMBER RANGER PART NUMBER DESCRIPTION 1 EPT690020Z ROTARY S

- 23 - PART LIST: RCI-6300F HP ANT P.C.B ITEM REFERENCE NUMBER RANGER PART NUMBER DESCRIPTION 1 EPT360042Z ANT P.C.B 2 R9 RCY010004Z 0 OHM

- 24 - PART LIST: RCI-6300F TB POWER P.C.B ITEM REFERENCE NUMBER RANGER PART NUMBER DESCRIPTION 1 EPA010010A POWER P.C.B 2 R904 RCU141094

- 25 - NUMBER 11 COPPER SIDE RCY011014Z 100 OHM 0.1W 12 C901 CC0501015A 100PF 50WV 13 C943 CC0500591A 0.5PF 50WV 14 C906,C926,C932, C937,TERMI

- 26 - PART LIST: RCI-6300F HP / RCI-6300F TB BAND SWITCH P.C.B ITEM REFERENCE NUMBER RANGER PART NUMBER DESCRIPTION 1 EPT630030Z BAND SWITCH

- 27 - PART LIST: RCI-6300F HP / RCI-6300F TB MIC P.C.B ITEM REFERENCE NUMBER RANGER PART NUMBER DESCRIPTION REMARK 1 EPT690050Z MIC P.C.B 2

- 28 -

- 2 - RCI-6300F HP RCI-6300F TB CHAPTER 1 SPECIFICATIONS 1.0 GENERAL Model RCI-6300F HP / RCI-6300F TB Frequency Range 28.245 - 29.655MHz. E

- 29 - PART LIST: RCI-6300F HP / RCI-6300F TB COUNTER P.C.B ITEM REFERENCE NUMBER RANGER PART NUMBER DESCRIPTION 1 EPT900040Z COUNTER P.C.B 2 R

- 30 - PART LIST: RCI-6300F HP / RCI-6300F TB LED DISPLAY P.C.B ITEM REFERENCE NUMBER RANGER PART NUMBER DESCRIPTION 1 EPT900022Z LED DIS

- 31 -

- 32 - PART LIST: RCI-6300F HP / RCI-6300F TB ECHO P.C.B (EB-99) ITEM REFERENCE NUMBER RANGER PART NUMBER DESCRIPTION 1 EPT0SSB50F ECHO P.C.B

- 33 - RCI-6300F HP / RCI-6300F TB MAIN PCB. REMARK: COPPER SIDE (WHITE)

- 34 - PART LIST RCI-6300F HP MAIN PCB REFERENCE NUMBER RANGER PART NO. DESCRIPTION EPT690010Z MAIN P.C.B R246 RCP164794Z 4.7 Ω 1/16W R267 RCP1

- 35 - 158,275,276 C80,181 CE0252267Z 22UF 25WV C37,175 CE0254767Z 47UF 25WV C107,156,238,293 CE0161077Z 100UF 16WV C152,179 CE0163377Z 330UF 16WV C9

- 36 - RCI-6300F HP MISC. PARTS REFERENCE NUMBER RANGER PART NO. DESCRIPTION - MM7878041B HEAT SINK - MT3001021X SET CHASSIS - MT3600050X DC

- 37 - PART LIST RCI-6300F TB MAIN PCB REFERENCE NUMBER RANGER PART NO. DESCRIPTION EPT690010Z MAIN P.C.B R246 RCP164794Z 4.7

- 38 - 50WV C78 CM0502245Z .22UF 50WV C10 CE0504747Z 0.47UF 50WV C67,75,153,157,170, 186,187,198 CE0501057Z 1UF 50WV C159,214,148 CE0502257Z 2.2UF 50

- 3 - RCI-6300F TB OPERATION Figure 2-1 Front Panel 2.0 INTRODUCTION This section explains the basic operating procedures for the RANGER RCI-6

- 39 - RCI-6300F TB MISC. PARTS REFERENCE NUMBER RANGER PART NO. DESCRIPTION - PT9000060K FRONT PANEL - PT9000020E CH KNOB - PT9000070

RCI-6300F HP SCHEMATIC DIAGRAM

RCI-6300F TURBO SCHEMATIC DIAGRAM

RCI-6300F HP EXPLODE DRAWING

RCI-6300F TURBO EXPLODE DRAWING

AT6300040A  COPYRIGHT 1999, RANGER COMMUNICATIONS INC.

- 4 - Adjusts the microphone gain in the transmit and PA modes. This controls the gain to the extent that full talk power is available several inches

- 5 - 17. S-RF/SWR SWITCH This is a two-function switch. In the S-RF position, the meter will indicate the strength of the signal being received, as

- 6 - Figure 2-2 Rear Panel 1. ANTENNA This jack accepts 50 ohms coaxial cable with a PL- 259 type plug. 2. POWER This connector accepts 13.8V DC

- 7 - 1 28.245 28.695 29.145 28.315 28.765 29.215 2 28.255 28.705 29.155 28.325 28.775 29.225 3 28.265 28.715 29.165 28.335 28.785 29.235 4 28.28

- 8 - 2.3 OPERATION 2.3.1 PROCEDURE TO RECEIVE 1. Be sure that power source, microphone and antenna are connected to the proper connectors before g